TRCM322522-R18J datasheet(6/7 Pages) TOKEN

6 / 7 page

06 of 07

Version 2010

TRCM Chip Wirewound Inductors

TRCM322522, TRCM453232 - Mechanical Performance Test

REQUIREMENTS

CHARACTERISTICS

TEST METHOD(DIS C 5321)

Terminal Strength

No evidence of damage

Terminals shall withstand a pull of 0.5Kgf

in a horizoninal direction

Vibration

Δ L/L shall be within ±3%.

No evidence of damage

2 hours in each direction of X,Y,Z on p-Board

at a frequency range of 10-55-10HZ with

1.5mm amplitude

Dropping

Δ L/L shall be within ±3%.

No evidence of damage

Dropping 1m over the ground of conctete or

cement

TRCM322522, TRCM453232 - Electrical Performance Test

REQUIREMENTS

CHARACTERISTICS

TEST METHOD(JIS C 5321)

Resistance to Soldering Heat

No evidence of damage

Δ L/L shall be within ±3%

Immerse in the solder (H63A) of 260±5°C for

10±1sec, leave for 2hrs at normal TEMP

Solderability

More than 90% surface to

be covered with new soldering

AV100V 60 SEC.

Dielectric with

standing voltage

No veridence of breakdown

resistor 1000 Mohm and over

DC500V 30 SEC.

Insulation Resistance

No veidence of breakdown,

resistor 1000 Mohm and over

DC 500V 30 SEC.

TRCM322522, TRCM453232 - Climatic Test

REQUIREMENTS

CHARACTERISTICS

TEST METHOD(JIS C 5321)

LOW TEMP. Characteristics

No evidence of damage,

Δ L/L within ±5%,

Q/Q within ±30%

Immerse in the solder (H63A)of 260±5°C

for 10±1sec, leave for 2hrs at normal TEMP.

TEMP. Cycling

No evidence of damage,

Δ L/L within ±5

Keep for 30 min. at TEMP.of -25°C~+85°

Cat 5 cycle case of TEMP. change from low to high

and V.V.

Temperature Characteristics

Δ L/L within ±3%

Δ L/L to be measured at the temperature

of between -25°C and +85°C

Moiisture load Characteristics

No evidence of damage,

Δ L/L within ±5%,

Q/Q within ±30

TEMP.40±2°C,Humidity 90~95% 96± 2hrs,

measurements shall be performed after 1~2hrs at

normal TEMP..

High TEMP. overload

Characteristics

No evidence of damage,Δ L/L

within ±5%,Q/Q within ±30

Leave for 96±2hrs in a bath of

TEMP.85±2°C,measurements shall be performed

after 1~2hrs at normal TEMP.

http://www.token.com.tw/

rfq token.com.tw

TOKEN

TRCM322522-R18J 数据表(PDF) 6 Page - Token Electronics Industry Co., Ltd.

TRCM322522-R18J 数据表(HTML) 6 Page - Token Electronics Industry Co., Ltd.

Html Pages

1 2 3 4 5 6 7

数据表下载

链接网址

TRCM322522-R18J 数据表(PDF) 6 Page - Token Electronics Industry Co., Ltd.

TRCM322522-R18J 数据表(HTML) 6 Page - Token Electronics Industry Co., Ltd.

Html Pages

1 2 3 4 5 6 7

数据表 下载

链接网址

数据表下载